SVX Network Forums Live Chat! SVX or Subaru Links Old Lockers Photo Post How-To Documents Message Archive SVX Shop Search |
IRC users: |
#16
|
||||
|
||||
Re: Cranks but won't start
Under rear seat…
Fuel pump modulator Rear wiper relay Auto Shoulder Belt Control unit… If you have one Keith |
#17
|
||||
|
||||
Re: Cranks but won't start
cool. thanks for all the info. The under-seat connector is 2 wires.
The 5 pin connector is at the top of the fuel tank, right underneath the cover in the trunk. Perhaps the 2 pin connector to the actual fuel pump is inside the tank? Either way, it's right on top of the fuel tank where the tubing comes out. If I want to hotwire the pump to test if it's still working, which 2 pins should I hook up to? Pin1 and Pin3 (yellow & blue)? I'll try to get some pictures whenever I work on it again. Which file shows where these fusible links are?
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me |
#18
|
||||
|
||||
Re: Cranks but won't start
Just checked the file F_BASIC_TESTING...has an entire fuel system test. I'll try that as well.
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me |
#19
|
||||
|
||||
Re: Cranks but won't start
I would be real careful hot wiring the fuel pump. Just splicing into a couple of wires could be a disaster.
If you disconnect the 2 wires to the fuel pump and fasten a 12 volt source to the pump itself, you should be fine, just to see if it runs. Isn't learning fun!! Hang in there, Keith |
#20
|
||||
|
||||
Re: Cranks but won't start
All I had time for this weekend was the starter fluid test...it started! It's good to know I'm barking up the right tree. Hopefully tonight I can test the entire circuit and see where I'm losing power!
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me |
#21
|
||||
|
||||
Re: Cranks but won't start
Problem is just pumping is not always good enough the injectors need like 90lb ( just a guess ) I had a weak pump in my 1991 Turbo and had gas but would not strart. Yes first see if it pumps at all.
|
#22
|
||||
|
||||
Re: Cranks but won't start
My understanding was that the fuel pump didn't run at all
Keith |
#23
|
||||
|
||||
Re: Cranks but won't start
Haven't tried running the pump mainly because i don't know what voltage to give it. I figure if I shoot it 12V for just a sec, i can at least hear it run or not run. But, ignoring that, my tests to this point show 0v @ the fuel pump when I turn the key to "on" or to "start" even though the relay is good. So, I need to figure out why there's no voltage getting there. That's what I hope to test for next. Then i can find out if the pump still works or not.
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me |
#24
|
||||
|
||||
Re: Cranks but won't start
*deleted - relay is fine*
Testing ECU outputs. Next is modulator and resistor. Anybody know how to drop the upper trunk trim without breaking all the clips?
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me Last edited by SVX10; 03-11-2009 at 08:19 PM. |
#25
|
||||
|
||||
Re: Cranks but won't start
I'm an idiot.
Battery. End of story.
__________________
Time for my very own long list of mods: 92 SVX LS-L - Ebony Pearl - 2002 WRX 5MT trans w/STi gearset (rebuilt & installed myself ) - BMW E46 HID retrofit - Kenwood Headunit - Phoenix Gold 75x4 RMS amp - Alpine Type R 6.5" front components - Alpine Type R 6x9 3way rear speakers - 18"x9" Rota G-Force wheels w/225/40ZR18 Toyo T1R's - Mychailo's custom springs - Urethane front & rear sway bar bushings - KC exhaust (2.5" dual magnaflow) - Escaine seat swap - Removed Spoiler I don't care if Subaru says it's STI...it will always be STi to me |
#26
|
|||
|
|||
Re: Cranks but won't start
lmao....good job finding the problem tho. hahahaha
__________________
Claret 92 Ls-l R.I.P - 24XXXX - kms "april 2008" rest in pieces Ebony black 92 Ls-l Alive - 25XXXX - Quick change, Powermod , Alternator Mod , audiobahn 1300 watt ach ,exile 800 watt peak, jackhammer 12" 300 watt rms, polkaudio 6 1/2 compoment. kenwood dvd\nav . radar detector.small car lens and grill |
#27
|
|||
|
|||
Re: Cranks but won't start
now i'm lost. didn't you say that it cranked all day? even started with a spray... |
#28
|
||||
|
||||
Re: Cranks but won't start
I have been following this thread. I thought its going to be something major
Now do you mean your battery is not producing enough voltage to ECU or starter Anyway, congrats on finding your problem.
__________________
94 Bordeaux Pearl SVX Lsi B&M cooler with Aux ATF filter. QC Kit Plus 06 Sti Gold Wheels. SOLD 92 Claret WRX 5 speed ECUTune 1AV1 Gold STI Wheels & more. SOLD 92 Teal SVX LSL lowered with Konig. SOLD 92 Black SVX LSL with B&M cooler & Aux filter. Small Car Shift Kit. Gone 94 Red SVX L FWDwith LSL Leather Interior. SOLD 92 Teal SVX LSL....with B&M cooler & Aux filter. Small Car Shift Kit. SOLD 95 Polo Green........With Trany Problem. GONE Almost complete Rear Wheel Bearings Job with Pictures in my locker My Locker http://www.subaru-svx.net/photos/user.php?pearlm30 |
Thread Tools | |
Display Modes | |
|
|